DMC脈沖布袋除塵器詳細介紹
PDM（DMC）系列噴吹脈沖單機袋式收塵器適用于破碎、輸送、提升、配料、庫頂、庫底、水泥散裝等處的粉塵治理，可以連續工作，無須停機清灰
●收塵器可分成不同的安裝形式：不帶灰斗及支腿型（B型）、帶灰斗及支腿型（A型）；風機可90°、0°，根據需要選擇
●壓縮空氣__0.5-0.7MPa的壓力，否則影響清灰效果
●除塵器本體采用碳鋼、不銹鋼等材質
●PMD（DMC） series jet-pulse unit bag filter is applicable for dust collecting in various sections, such as crushing, conveying, elevating, proportioning, silo top, silo bottom and bulk cement. It could operate continuously without necessity to stop the equipment for removing dust.
●The dust collector could be erectly in different ways: without hopper and bracing（B model）; with hopper and long bracing（A model）; Fans can be set in 90°ａnd 0°angles depending on requirements.
●Pressure of compressed air should be ensured within0.5-0.7MPA，or else operation for removing dust would not be efficient.
●Use the material such as carbon steel, stainless steel filter ontology.
【特點介紹Characteristics】
●一般采用上箱體頂部設可掀起的蓋板用于檢修及_換濾袋，若空間受限可采用側開門以便檢修_換濾袋。
●濾袋用特制的彈簧脹圈固定在多孔板上，濾袋內安裝有金屬框架和文氏管。
●采用微機自動控制清灰
●安裝有防濾袋脫落網，_適合庫頂使用
●General use case on the top cover plate for convenient maintenance and replacement of bag. If the space is limited side door can be used to repair replace the filter bag.
Filter bag with a special spring ring fixed on the perforated plate , Metal frame and pipe installation within the filter bag
Dust removal is controlled by computer automatically.
●收塵器入口含塵濃度一般低于200g/Nm3
●收塵器排放濃度低于30mg/Nm3
●收塵器濾袋壽命兩年以上
●收塵器運轉率相對主機99.9%
●Dust concentration at inlet is below 200 g/Nm3.
●Emission concentration is below 20 mg/Nm3.
●Service life of filter bags is over 2 years.
●The operation rate of bag filter to equipment is 99.9%
【規格與性能參數表Specification】
規格型號 Type 參數 Parameter | DMC-24 | DMC-36 | DMC-48 | DMC-60 | DMC-72 | DMC-84 | |
PMD-24 | PMD -36 | PMD-48 | PMD-60 | PMD -72 | PMD-84 | ||
處理風量 Capacity（m3/h） | 1300-2000 | 1800-3200 | 2500-4000 | 3500-5500 | 4100-6500 | 5000-7500 | |
過濾面積 Filtration area（m2） | 19 | 30 | 39 | 58 | 68 | 81 | |
濾袋數量（個）Φ133×2000 Number of filter bags Φ133×2000 | 24 | 36 | 48 | 60 | 72 | 84 | |
過濾風速 Velocity of filtering air（m/min） | 0.8-1.8（工況不同，濾材不同均影響此參數選取，歡迎來電來函咨詢） （This parameter is influenced different working conditions and filter materials. You are welcome to write or cable for information.） | ||||||
阻力 Resistance（Pa） | ≤1200 | ||||||
進口含塵濃度 Dust concentration at inlet（g/Nm3） | ＜200 | ||||||
出口排放濃度 Emission concentration at outlet（mg/Nm3） | ＜30 | ||||||
脈沖閥數量 Number of pulse valve | 4 | 6 | 8 | 10 | 12 | 16 | |
脈沖閥規格Specifications of pulse valve | 1’’ | ||||||
清灰壓縮空氣Compressed Air for removing dust | 壓力 Pressure（MPa） | 0.5-0.7 | |||||
耗量 Volume（m3/min） | 0.15 | 0.2 | 0.27 | 0.25 | 0.31 | 0.35 | |
【規格與性能參數表Specification】
規格型號 Type 參數 Parameter | DMC-96 | DMC-112 | DMC-120 | DMC-132 | DMC-143 | DMC-165 | |||
| PMD-96 | PMD-112 | PMD-120 | PMD-132 | PMD-143 | PMD-165 | |||
處理風量 Capacity（m³/h） | 6500-8000 | 7200-9200 | 8200-9900 | 9500-11600 | 10500-12500 | 11500-14500 | |||
過濾面積 Filtration area（m²） | 88 | 103 | 110 | 121 | 132 | 152 | |||
濾袋數量（個）Φ130×2200 Number of filter bags Φ130×2200 | 96 | 112 | 120 | 132 | 144 | 165 | |||
過濾風速 Velocity of filtering air（m/min） | 0.8-1.8（工況不同，濾材不同均影響此參數選取，歡迎來電來函咨詢） （This parameter is influenced different working conditions and filter materials. You are welcome to write or cable for information.） | ||||||||
阻力 Resistance（Pa） | ≤1200 | ||||||||
進口含塵濃度 Dust concentration at inlet（g/Nm³） | ＜200 | ||||||||
出口排放濃度 Emission concentration at outlet（mg/Nm³） | ＜30 | ||||||||
脈沖閥數量 Number of pulse valve | 12 | 14 | 16 | 12 | 13 | 15 | |||
脈沖閥規格Specifications of pulse valve | 1’’ | 1.5’’ | |||||||
清灰壓縮空氣Compressed Air for removing dust | 壓力 Pressure（MPa） | 0.5-0.7 | |||||||
| 耗量 Volume（m³/min） | 0.35 | 0.4 | 0.5 | 0.6 | 0.75 | 0.95 | ||
